Solving the symbols In this Workshop Manual for the F 650 GS model, the following symbols are used; their meanings are explained in the table. Special instructions aimed at improving the work procedures. Note. Specific information on operating, inspecting and adjusting...
General view of crated motorcycle Checking the shipping crate for damage When the motorcycle arrives, check the crate immediately for damage and if necessary examine the contents for consequential damage. In case of damage in Germany Note the damage on the delivery slip. Read the...
Unpacking the motorcycle Lever off the cover. Take out the separate pack of items. Force off cross-struts with a suitable lever. Caution: Do not hammer out the cross-strut panels or the motorcycle may be damaged. Remove the end panels. Remove the side panels. Caution! Make...
Installing remaining items on motorcycle Installing windscreen Wheel the motorcycle clear of the wooden pallet. Tighten the windscreen securing screws. Tightening torques: Windscreen to cockpit fairing — 2 Nm. Installing front mudguard, mirrors and handlebar weights Install front mudguard....
Filling and charging the battery Removing right and centre covers Note: Do not remove the windscreen after the side panels have been removed, as otherwise the headlight beam setting will have to be checked. Remove the lid of the stowage compartment. Remove the seat. Remove the...
Reading the fault code memory with the BMW MoDiTeC Unclip diagnosis plug (1) behind cover on right. Connect the diagnosis unit to the diagnosis plug. Read out the fault memory. Perform all requisite repair work. Clip diagnosis plug into position behind cover on right.
Checking tyre pressures Check/correct tyre pressures. Tyre pressures: Solo front 1.9 bar (27.0 psi) rear 2.1 bar (29.9 psi) With full load front 2.1 bar (29.9 psi) rear 2.3 bar (32.7 psi)
Final inspection and function check Note. When the motorcycle arrives, the oil level in the tank might be below the sight glass. Oil check: if oil is not visible in the sight glass, check whether the oil tank (2) contains oil. Clutch. Check gear shift action. Steering. Front and rear...