Engine electronic control module — diagnostic trouble codes (Triumph Street Triple 765 R/RS)

0

Diagnostic trouble codes (DTCs) are logged in the ECM memory when there is a confirmed fault in the system.

The codes are reported to the Triumph diagnostic software as a four digit code.

As mentioned earlier, when the system detects a fault, it begins to count the number of times the fault occurs before illuminating the MIL and storing a fault code.

Similarly, if a fault clears, the ECM also records this fact and will turn off the MIL when sufficient no fault warm-up cycles have taken place. Any fault codes will remain in the ECM memory until the required number of no fault warm-up cycles have taken place. The number of warm-up cycles required to extinguish the MIL will always be less than the number required to remove a DTC from the ECM memory. DTCs can be removed at any time using the Triumph diagnostic software.

The system will log the diagnostic trouble codes listed below/over:

Diagnostic Trouble Code (DTC)	Fault Description	Number of no-fault cycles before turning off MIL	Number of no-fault cycles before DTC is erased	MIL illuminated when fault is logged	Pinpoint test page number
P0030	Oxygen sensor 1 heater open circuit or short to ground	3	40	Yes	Oxygen Sensor Heater
P0032	Oxygen sensor 1 heater short circuit to battery Voltage	3	40	Yes	Oxygen Sensor Heater
P0105	Manifold absolute pressure sensor 1 open circuit or short circuit to 5 Volt sensor supply	3	40	Yes	Manifold Absolute Pressure (MAP) Sensor
P0107	Manifold absolute pressure sensor 1 short circuit to ground	3	40	Yes	Manifold Absolute Pressure (MAP) Sensor
P0110	Intake air temperature sensor open circuit or short circuit to 5 Volt sensor supply	3	40	Yes	Inlet Air Temperature Sensor
P0112	Intake air temperature sensor short circuit to ground	3	40	Yes	Inlet Air Temperature Sensor
P0115	Engine coolant temperature sensor open circuit or short circuit to 5 Volt sensor supply	3	40	Yes	Coolant Temperature Sensor
P0117	Engine coolant temperature sensor short circuit to ground	3	40	Yes	Coolant Temperature Sensor
P0120	Throttle position sensor 1 short circuit or open circuit	3	40	Yes	Throttle Position Sensor
P0122	Throttle position sensor 1 short circuit to ground or open circuit	3	40	Yes	Throttle Position Sensor
P0130	Oxygen sensor 1 open circuit or short circuit to battery Voltage	3	40	Yes	Oxygen Sensor
P0131	Oxygen sensor 1 short circuit to ground	3	40	Yes	Oxygen Sensor
P0201	Injector 1 circuit malfunction	3	40	Yes	Fuel Injectors
P0202	Injector 2 circuit malfunction	3	40	Yes	Fuel Injectors
P0203	Injector 3 circuit malfunction	3	40	Yes	Fuel Injectors
P0220	Throttle position sensor 2 short circuit to battery Voltage or open circuit	3	40	Yes	Throttle Position Sensor
P0222	Throttle position sensor 2 short circuit to ground	3	40	Yes	Throttle Position Sensor
P0335	Crankshaft sensor circuit malfunction	3	40	Yes	Crankshaft Sensor
P0351	Ignition coil 1 malfunction	3	40	Yes	Ignition Coils
P0352	Ignition coil 2 malfunction	3	40	Yes	Ignition Coils
P0353	Ignition coil 3 malfunction	3	40	Yes	Ignition Coils
P0412	Secondary air injection short circuit to ground or open circuit	3	40	Yes	Secondary Air Injection Valve
P044F	Secondary air injection short circuit to battery Voltage	3	40	Yes	Secondary Air Injection Valve
P0443	Purge valve short circuit to ground or open circuit	3	40	Yes	Purge Valve
P0459	Purge valve short circuit to battery Voltage	3	40	Yes	Purge Valve
P0460	Fuel level sensor circuit malfunction	0	40	No	Fuel Level Sensor Circuit
P0560	System voltage - battery circuit malfunction	3	40	Yes	System Voltage
P0571	Brake switch 1 malfunction	0	40	Yes	Brake Switches
P0603	EEPROM Error	0	40	No	EEPROM Error
P0606	ECM internal error	0	0	Yes	Engine ECM Internal Error
P0616	Starter relay short circuit to ground or open circuit	3	40	Yes	Starter Motor Relay
P0617	Starter relay short circuit to battery Voltage	3	40	Yes	Starter Motor Relay
P0914	Gear position sensor short circuit to ground or open circuit	3	40	Yes	Gear Position Sensor
P0917	Gear position sensor short circuit to 5 Volt sensor supply	3	40	Yes	Gear Position Sensor
P1105	Manifold absolute pressure sensor 1 pipe malfunction	3	40	Yes	Manifold Absolute Pressure (MAP) Sensor
P1135	Traction Control prevented due to ABS malfunction	3	40	Yes	Traction Control Disabled Due to ABS Malfunction
P1231	Fuel pump relay short circuit to ground or open circuit	3	40	Yes	Fuel Pump Relay
P1232	Fuel pump relay short circuit to battery Voltage	3	40	Yes	Immobiliser and TPMS Control Module ID Incompatible
P1508	Unmatched Immobiliser ECM	3	40	Flashing	Immobiliser and TPMS Control Module ID Incompatible
P1520	Unmatched ABS module	3	40	Flashing	ABS Modulator ID Incompatible
P1521	CAN fault - lost communication with ABS module or ABS system status error	3	40	Yes	ABS Modulator Communication
P1552	Cooling fan relay short circuit to ground or open circuit	3	40	Yes	Cooling Fan Relay
P1553	Cooling fan relay short circuit to battery Voltage or over temp	3	40	Yes	Cooling Fan Relay
P1571	Brake switch 2 malfunction	3	40	Yes	Brake Switches
P1576	Brake switch 1 correlation error with brake switch 2	3	40	Yes	Brake Switches
P1577	Brake switch 2 correlation error with brake switch 1	3	40	Yes	Brake Switches
P1604	ECM tamper detected - return to Triumph	0	0	Yes	Engine ECM Tamper Detected
P1605	ECM locked by the tune lock function	Only if tune lock is unlocked		Flashing	ECM locked by the Calibration Lock Function
P1607	ECM ride by wire internal error	3	40	Yes	Engine ECM Internal Error
P1608	ECM ride by wire internal error	3	40	Yes	Engine ECM Internal Error
P1614	Instrument ID incompatible	Only if Instrument ID Matching		Flashing	Instrument ID Incompatible
P1619	Headlamp relay short circuit to ground or open circuit	0	40	No	Headlight Relay
P1620	Headlamp relay short circuit to battery Voltage	0	40	No	Headlight Relay
P1631	Fall detection circuit short circuit to ground	3	40	Yes	Fall Detection Switch
P1632	Fall detection circuit short circuit to battery Voltage	3	40	Yes	Fall Detection Switch
P1650	CAN fault - lost communication with Immobiliser ECM	3	40	Yes	Immobiliser Control Module Communication
P1659	Ignition power supply malfunction	3	40	Yes	EMS Ignition Voltage Input Circuit
P1685	Main relay circuit malfunction	3	40	Yes	EMS Main Relay Circuit
P1690	CAN Fault	3	40	Yes	CAN Communication
P1695	CAN fault - lost communication with instrument panel	0	40	No	Instrument Communication (CAN)
P1698	5 Volt sensor supply malfunction	3	40	Yes	5 Volt Sensor Supply Circuit
P2100	Throttle actuator control motor open circuit	3	40	Yes	Throttle Actuator Motor
P2102	Throttle actuator control internal motor relay does not operate	3	40	Yes	Throttle Valve Drive Error
P2103	Throttle actuator control internal motor relay operates continually	3	40	Yes	Throttle Valve Drive Error
P2111	Throttle valve drive error (stuck open)	3	40	Yes	Throttle Valve Drive Error
P2119	Throttle valve drive error	3	40	Yes	Throttle Valve Drive Error
P2120	Twist grip position sensor 1 short circuit to ground or open circuit	3	40	Yes	Twist Grip Position 1
P2123	Twist grip position sensor 1 short circuit to battery Voltage	3	40	Yes	Twist Grip Position 1
P2125	Twist grip position sensor 2 short circuit to ground or open circuit	3	40	Yes	Twist Grip Position 2
P2128	Twist grip position sensor 2 short circuit to vBatt	3	40	Yes	Twist Grip Position 2
P2135	Throttle position sensor 1 correlation error with throttle position sensor 2	3	40	Yes	Throttle Position Sensor
P2138	Twist grip position sensor 1 correlation error with twist grip position 2	3	40	Yes	Twist Grip Position Sensor 1 Correlation Error with Twist Grip Position 2
P2226	Ambient air pressure sensor circuit open circuit or short circuit to 5 Volt sensor supply	3	40	Yes	Ambient Air Pressure Sensor
P2228	Ambient air pressure sensor circuit short circuit to ground	3	40	Yes	Ambient Air Pressure Sensor

(The article is based on materials from the website: motoinstruction.ru)

See this article in russian language

ECM (Engine Control Module) — removal and installation Honda VTX 1800 C (2001-2008)
Electronic control module: ECM — removal and installation Harley-Davidson V-Rod (2002-2006)
Electronic control unit Ducati ST2 (1997-2003)
Removing the engine control unit Aprilia RS 125/3 (1998-2005)
DTC (Diagnostic Trouble Code) Output Suzuki 1000A/XA V-Strom (2014-2019)

Article about repair motorcycles «Triumph Street Triple 765 R/RS» (2017-2024): «Engine electronic control module — diagnostic trouble codes»: https://motoinstruction.ru/en/Triumph/Street-Triple/4/engine/fuel/113890 <a href="https://motoinstruction.ru/en/Triumph/Street-Triple/4/engine/fuel/113890">Engine electronic control module — diagnostic trouble codes</a> - article about repair motorcycles «Triumph Street Triple 765 R/RS» (2017-2024) from section «Fuel and control system». [url=https://motoinstruction.ru/en/Triumph/Street-Triple/4/engine/fuel/113890]Engine electronic control module — diagnostic trouble codes[/url] - article about repair motorcycles «Triumph Street Triple 765 R/RS» (2017-2024) from section «Fuel and control system».